replacement of fine aggregate with quarry dust in geopolymer concrete

Study on Performance of Quarry Dust as Fine Aggregate in ...

The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%, 40%, 60%, 80% partial replacement of ...

More

Introduction to Quarry-Dust as Partial Replacement ...

QUARRY DUST AS FINE AGGREGATE: EFFECT ON COMPRESSIVE STRENGTH , DURABILITY AND WORKABILITY OF CONCRETE. The experimental study done by R Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao.[6] in which replacement of the sand with quarry dust shows an improvement in the compressive strength of the concrete. The investigation concludes that, as the replacement

More

Studies on Quarry Dust as Partial Replacement of Fine ...

Natural sand is most commonly used fine aggregates in the production of concrete possess the problem of acute shortage in many areas. Quarry dust can be used as an economic alternative to the natural sand. In this investigation an attempt is made to

More

Feasibility of Quarry Dust to Replace River Sand as Fine ...

Feasibility of Quarry Dust to Replace River Sand as Fine Aggregate of Concrete R W C N Rajapaksha and H P Sooriyaarachchi Abstract: High cost and scarcity of river sand is one of the main problem faced by construction industry today. Use of substitutions like offshore sand in particular to replace river sand is on the rise. Quarry dust is another alternative for river sand. However, full ...

More

An Experimental Investigation on GGBSand Flyash Based ...

Geopolymer Concrete with Replacement of Sand by Quarry Dust Maneeshkumar C S1,Manimaran G2, Prasanth S3 1 ... Fine aggregate used in this research is river sand. Fineaggregates are the aggregates whose size is less than4.75mm. Sand is generally considered to have a lowersize limit of about 0.07mm, also free from clay, mineralsand salt. Table.III Properties of Fine aggregate SI No

More

Suitability of Quarry Dust as a Partial Replacement of ...

To overcome this problem, present study is focused on the suitability to utilize the quarry dust in Self Compacting Concrete (SCC) partially as fine aggregate with the natural fine aggregates. In this work, quarry dust is used as replacement of sand in a different level (0%, 15%, 30%, 45% and 60%) for producing the SCC. Fresh properties such as slump flow and V-funnel time have been measured ...

More

quarry dust in geopolymer concrete

replacement of fine aggregate with quarry dust in geopolymer concrete. Geopolymer concrete is an innovative construction ... the fine aggregate shall be replaced ... Geopolymer Concrete by partial replacement of quarry dust. Continue Reading →

More

Utilization of Stone Dust as Fine Aggregate Replacement in ...

maximum strength was obtained at 60% replacement of fine aggregate with stone dust. The results shows strength of concrete increases within 5-12 percent up to 50 percent replacement of fine aggregate. And at 60 percent stone dust in concrete the maximum value of compressive strength is obtained which is 17

More

REPLACEMENT OF FINE AGGREGATE WITH JAROFIX IN CONCRETE

[26] reveal that the fine aggregate in concrete replaced with 75% quarry dust waste gives the required compressive strength for construction industry. Obilade [15] studied the presence of rice husk as fine aggregates in concrete. The percentage replacement was 0%, 5%, 10%, 15%, 20% and 25%. The results revealed that the Compacting Factor, Bulk Density and Compressive strength decreased as

More

Use of Quarry Dust to Replace Sand in Concrete – An ...

at 50% replacement. Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today. The constituents of concrete are coarse aggregate, fine aggregate, binding material and water. Rapid increase in construction activities leads to acute shortage of conventional construction materials. It is conventional that sand is ...

More

Compressive strength study of Geopolymer Mortar

One of the alternative is the use of quarry dust in replacement to sand as fine aggregate. Hence, in scheme of reducing the environmental hazards due to the ingredients of concrete production the present research deals with the study of compressive strength of geopolymer mortar which is a combination of GGBFS flyash (in replacement of cement), Quarry rock dust (in replacement of sand), and 12 ...

More

Study on Compressive Strength of Quarry Dust as Fine ...

The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

More

IOP Conference Series: Materials Science and Engineering ...

Abstract: The replacement of natural fine aggregate by using quarry dust leads to consumption of generated quarry dust, the requirement of land fill area can be reduced and solves the natural sand scarcity problem. The sand availability as a fine aggregate at low cost which needs the reason to search as a alternative material. Even it causes saddle to dump the crusher dust at one place which ...

More

Studies on Quarry Dust as Partial Replacement of Fine ...

Natural sand is most commonly used fine aggregates in the production of concrete possess the problem of acute shortage in many areas. Quarry dust can be used as an economic alternative to the natural sand. In this investigation an attempt is made to

More

Suitability of Quarry Dust as a Partial Replacement of ...

To overcome this problem, present study is focused on the suitability to utilize the quarry dust in Self Compacting Concrete (SCC) partially as fine aggregate with the natural fine aggregates. In this work, quarry dust is used as replacement of sand in a different level (0%, 15%, 30%, 45% and 60%) for producing the SCC. Fresh properties such as slump flow and V-funnel time have been measured ...

More

An Experimental Investigation on GGBSand Flyash Based ...

Geopolymer Concrete with Replacement of Sand by Quarry Dust Maneeshkumar C S1,Manimaran G2, Prasanth S3 1 ... Fine aggregate used in this research is river sand. Fineaggregates are the aggregates whose size is less than4.75mm. Sand is generally considered to have a lowersize limit of about 0.07mm, also free from clay, mineralsand salt. Table.III Properties of Fine aggregate SI No

More

Studies on quarry dust as partial replacement of fine ...

05/05/2017  CONCLUSIONS In this experimental investigation, an attempt has been made to use Quarry dust to replace the fine aggregates in concrete. Following are some of the conclusions drawn from the results ...

More

Effect of Quarry Dust on Class C Fly Ash Concrete

Effect of Quarry Dust on Class C Fly Ash Concrete V. Sri Raman1, R.Venkatakrishnaiah2 1 ... literature available on the use of Class F fly ash as partial replacement of fine aggregates [10–14]. Maslehuddinet al. [10] carried out investigations to evaluate the compressive strength development and corrosion-resisting characteristics of concrete mixes in which fly ash was used as an admixture ...

More

Investigating Strength Properties of Geopolymer Concrete ...

To address the environmental constraints due to cement production and sand scarcity, strength properties of high-calcium fly ash (CFA)-based geopolymer concrete with quarry dust as fine aggregate is explored in this paper. River sand was replaced with quarry dust from 0 to 100% by mass. Sodium hydroxide solution with 8M and 14M concentration, alkaline liquid-to-fly ash ratios of 0.50 and

More

REPLACEMENT OF FINE AGGREGATE WITH JAROFIX IN CONCRETE

[26] reveal that the fine aggregate in concrete replaced with 75% quarry dust waste gives the required compressive strength for construction industry. Obilade [15] studied the presence of rice husk as fine aggregates in concrete. The percentage replacement was 0%, 5%, 10%, 15%, 20% and 25%. The results revealed that the Compacting Factor, Bulk Density and Compressive strength decreased as

More

Compressive strength study of Geopolymer Mortar

One of the alternative is the use of quarry dust in replacement to sand as fine aggregate. Hence, in scheme of reducing the environmental hazards due to the ingredients of concrete production the present research deals with the study of compressive strength of geopolymer mortar which is a combination of GGBFS flyash (in replacement of cement), Quarry rock dust (in replacement of sand), and 12 ...

More

IOP Conference Series: Materials Science and Engineering ...

Abstract: The replacement of natural fine aggregate by using quarry dust leads to consumption of generated quarry dust, the requirement of land fill area can be reduced and solves the natural sand scarcity problem. The sand availability as a fine aggregate at low cost which needs the reason to search as a alternative material. Even it causes saddle to dump the crusher dust at one place which ...

More

Studies on quarry dust as partial replacement of fine ...

05/05/2017  CONCLUSIONS In this experimental investigation, an attempt has been made to use Quarry dust to replace the fine aggregates in concrete. Following are some of the conclusions drawn from the results ...

More

Strength Studies On Geo-Polymer Concrete by using Fly Ash ...

Strength Studies On Geo-Polymer Concrete by using Fly Ash And Quarry Dust K ... Geopolymer concrete is such a one and in the present study, to produce the geo-polymer concrete the Portland cement is fully replaced with fly ash and the fine aggregate is replaced with quarry dust and alkaline liquids are used for the binding of materials. The alkaline liquids used in this study for the ...

More

Effect of Quarry Dust on Class C Fly Ash Concrete

Effect of Quarry Dust on Class C Fly Ash Concrete V. Sri Raman1, R.Venkatakrishnaiah2 1 ... literature available on the use of Class F fly ash as partial replacement of fine aggregates [10–14]. Maslehuddinet al. [10] carried out investigations to evaluate the compressive strength development and corrosion-resisting characteristics of concrete mixes in which fly ash was used as an admixture ...

More

GEOPOLYMER CONCRETE A REVIEW - ijeset

Since there is demand for natural sand, the fine aggregate shall be replaced partially by quarry dust. Quarry dust is having high content of Silica, which may increase the compressive strength of Geopolymer Concrete by partial replacement of quarry dust. Different concentrations of Sodium

More

REPLACEMENT OF FINE AGGREGATE WITH JAROFIX IN CONCRETE

[26] reveal that the fine aggregate in concrete replaced with 75% quarry dust waste gives the required compressive strength for construction industry. Obilade [15] studied the presence of rice husk as fine aggregates in concrete. The percentage replacement was 0%, 5%, 10%, 15%, 20% and 25%. The results revealed that the Compacting Factor, Bulk Density and Compressive strength decreased as

More

EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY PARTIAL ...

inhibitors in concrete containing quarry dust as fine aggregate,”Journal of Engineering and Applied Sciences, vol. 6, no. 11, pp. 124–135, 2011. [7] R. P. Nanda, A. K. Das, and N. Moharana, “Stone crusher dust as a fine aggregate in concrete for paving blocks,” International Journal of Civil and Structural Engineering, vol.

More

Can we make concrete using quarry dust as a

Yes As quarry dust(also called as crushed sand) is a byproduct obtained after crushing of stones(rocks) to make aggregates. * Results have shown that the concrete ...

More

EXPERIMENTAL INVESTIGATION OF STRENGTH AND

CHARACTERISTICS OF GEOPOLYMER CONCRETE BY USING FLYASH AND QUARRY DUST D.Priyadharshini1, Dr.R.Saravanan2 ... a gel which binds fine and coarse aggregates. Since geopolymer concrete is an emerging field, the guide lines from the bureau of Indian standards are yet to be formulated. An attempt has been made to find out an optimum mix for geopolymer concrete. Concrete

More

(PDF) Study on Compressive Strength of Quarry Dust as

The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced

More

Partial Replacement of Fine Aggregates with Quarry

The study aims to determine the strength properties of concrete by replacing sand with quarry dust for M30 grade with 20%, 25% and 30% replacement. It is observed that for 20% of quarry dust (3 days, 7 days, 28 days) the average compressive strength

More

IOP Conference Series: Materials Science and Engineering ...

Abstract: The replacement of natural fine aggregate by using quarry dust leads to consumption of generated quarry dust, the requirement of land fill area can be reduced and solves the natural sand scarcity problem. The sand availability as a fine aggregate at low cost which needs the reason to search as a alternative material. Even it causes saddle to dump the crusher dust at one place which ...

More

Effect of Marble Powder and Quarry Dust as Partial ...

This project deals with the experimental study of the characteristic strength of concrete using quarry dust as a complete replacement of river sand fine aggregate tested at 7 and 28 days. This paper report the experimental study which investigated the influence of 100% replacement of sand with quarry dust. Samples of concrete (cubes and cylinders) for one mix, namely 1:1.02:2.22 were made ...

More

Experiment on Foam Concrete with Quarry Dust as Partial ...

concrete is quarry dust as partial material replacement for fine aggregate. Quarry dust is classified as fine material obtained from the crushing process during quarrying activity at the quarry site. In this study, quarry dust will be studied as e aggregate. Quarry dust has been use for different activities in the construction industry such as for road construction and manufacture of building ...

More

Studies on quarry dust as partial replacement of fine ...

05/05/2017  CONCLUSIONS In this experimental investigation, an attempt has been made to use Quarry dust to replace the fine aggregates in concrete. Following are some of the conclusions drawn from the results ...

More

replacement of fine aggregate with quarry dust in ...

replacement of fine aggregate with quarry dust in geopolymer concrete. particles less than 4.75mm. Usually, Quarry Rock Dust is used in large scale in the highways as a surface finishing material and also used for manufacturing of hollow blocks and lightweight concrete prefabricated Elements.

More

REPLACEMENT OF FINE AGGREGATE WITH JAROFIX IN CONCRETE

[26] reveal that the fine aggregate in concrete replaced with 75% quarry dust waste gives the required compressive strength for construction industry. Obilade [15] studied the presence of rice husk as fine aggregates in concrete. The percentage replacement was 0%, 5%, 10%, 15%, 20% and 25%. The results revealed that the Compacting Factor, Bulk Density and Compressive strength decreased as

More

Stone Dust in Concrete: Effect on Compressive Strength

using stone dust as partial replacement of fine aggregate in the range of 10% - 100%. M25 grade of concrete was designed using Portland pozzolana cement (PPC) for referral concrete. Workability and Compressive strength were determined at different replacement level of fine aggregate viz a viz referral concrete and optimum replacement level was determined based on compressive strength. Results ...

More

EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY PARTIAL ...

inhibitors in concrete containing quarry dust as fine aggregate,”Journal of Engineering and Applied Sciences, vol. 6, no. 11, pp. 124–135, 2011. [7] R. P. Nanda, A. K. Das, and N. Moharana, “Stone crusher dust as a fine aggregate in concrete for paving blocks,” International Journal of Civil and Structural Engineering, vol.

More

Copyright © 2020.Company name All rights reserved.SiteMap